July 11, 2019 NHTSA CAMPAIGN NUMBER: 19V520000
Ground Wire May Short-Circuit and Cause Fire
A melted grounding wire may result in a short-circuit, increasing the risk of a fire in the engine compartment.
NHTSA Campaign Number: 19V520
Manufacturer Corp. Micro Bird Inc.
Components ELECTRICAL SYSTEM
Potential Number of Units Affected 52
Summary
Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2019 MBII propane-powered vehicles equipped with a main battery cut-off switch. If the main battery cut-off switch is activated, the propane conversion controller grounding wire may melt.
Remedy
Micro Bird will notify owners and dealers will relocate the grounding, free of charge. The recall began August 6, 2019. Owners may contact Micro Bird customer service at 1-819-477-2012, extension 364.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall 19-082-GUS / NHTSA Recall # 19V520
(Ground Relocation – Propane Bus)
IMPORTANT SAFETY RECALL NOTICE
This notice applies to your vehicle(s) appearing on the attached list
August 2019
This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act.
What is being recalled?
Micro Bird has decided that a defect which relates to motor vehicle safety exists in MBII models, built on Ford
chassis, year models 2019 propane-powered school buses manufactured between March 20th, 2019 and June 30th, 2019 and equipped with a main battery cut-off switch.
Why is it being recalled?
Micro Bird has determined that, in propane-powered vehicle equipped, as per supplier instructions, the propane conversion controller grounding wire is attached directly on the main battery ground post. When the vehicle is equipped with a main battery cut-off switch, if the main battery cut-off switch is activated, under certain conditions, the sleeve of the grounding wire may melt and cause failure to the propane module.
What is the safety issue?
If the sleeve of the grounding wire melts, a short circuit may happen, possibly causing a fire to ignite in the engine compartment.
What are we asking you to do?
- Immediately locate the affected unit(s) in your fleet and relocate the ground according to the attached instructions.
- For reimbursement, complete the reply sheet for each repaired vehicle and send it back to Micro Bird Corporation Inc. by fax at 819 475 9633 or by email at [email protected]. This will enable us to update our files
What Micro Bird Corporation will do?
Micro Bird Corporation is providing a field modification instruction to mitigate this recall at no charge. It will be the responsibility of the bus owners to execute the mitigation.
Should Micro Bird Corporation Inc. fail or be unable to remedy the situation without charge, you may contact:
Associate Administrator, National Highway Traffic Safety Administration
1200 New Jersey Ave S.E., Washington, DC 20590
Phone: (888) 327-4236 (TTY: 1-800-424-9153); or go to
https://www.safercar.gov
Changed address or sold the vehicle?
If you have changed address, or have sold the vehicle, please complete the form at the end of this letter, sign and date it, then send it to Micro Bird Corp. by fax at 819 475-9633 or by email at [email protected] so we can update our records. You can also contact us by phone at 819 477-2012 extension 364. The information you provide will be used to notify the new owner about this recall. If you have leased this vehicle to another person or organization, you must forward this letter to the lessee within ten (10) days.
We apologize for this situation and want to assure you that, with your assistance, we will correct this condition.
Best regards,
Marie Claude Gagnon
Regulations and Standards Technician Micro Bird Corporation Inc.
Micro Bird Corporation Inc., 3000 Girardin, Drummondville (Quebec) J2E 0A1
| DATE: | July 2019 |
| TO: | Micro Bird Distributors |
| SUBJECT: | Recall # 19-082 |
FROM: Marie Claude Gagnon, Regulations and Standards Technician, Micro Bird Inc.
This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act.
What is being recalled?
Micro Bird has decided that a defect which relates to motor vehicle safety exists in MBII models, built on Ford chassis, year models 2019 propane-powered school buses manufactured between March 20th, 2019 and June 30th, 2019 and equipped with a main battery cut-off switch.
Why is it being recalled?
Micro Bird has determined that, in propane-powered vehicle equipped, as per supplier instructions, the propane conversion controller grounding wire is attached directly on the main battery ground post. When the vehicle is equipped with a main battery cut-off switch, if the main battery cut-off switch is activated, under certain conditions, the sleeve of the grounding wire may melt and cause failure to the propane module.
What is the safety issue?
If the sleeve of the grounding wire melts, a short circuit may happen, possibly causing a fire to ignite in the engine compartment.
What are we asking you to do?
- Immediately locate the affected unit(s) in your fleet and relocate the ground according to the attached instructions.
- For reimbursement, complete the reply sheet for each repaired vehicle and send it back to Micro Bird Corporation Inc. by fax at 819 475 9633 or by email at [email protected]. This will enable us to update our files
What Micro Bird Corporation will do?
Micro Bird Corporation is providing a field modification instruction to mitigate this recall at no charge. It will be the responsibility of the bus owners to execute the mitigation.
We apologize for any inconvenience this action may have caused and we thank you for your cooperation.
Best regards,
Marie Claude Gagnon
Regulations and Standards Technician Micro Bird Corporation Inc.
1 Affected Product
Vehicle
| MICRO BIRD | MB II | 2019 |
10 Associated Documents
Manufacturer Notices(to Dealers,etc)
RCMN-19V520-7209.pdf 306.966KB
Defect Notice 573 Report
RCLRPT-19V520-7828.PDF 212.541KB
Recall Acknowledgement
RCAK-19V520-2936.pdf 245.579KB
Recall 573 Report- Amendment 1
RCLRPT-19V520-6818.PDF 212.541KB
Recall Quarterly Report #2, 2019-4
RCLQRT-19V520-7410.PDF 211.236KB
Recall Quarterly Report #3, 2020-1
RCLQRT-19V520-5376.PDF 211.321KB
Recall 573 Report- Amendment 3
RCLRPT-19V520-6404.PDF 212.622KB
Recall 573 Report- Amendment 2
RCLRPT-19V520-1854.PDF 212.55KB
Owner Notification Letter(Part 577)
RCONL-19V520-9455.pdf 396.315KB
Recall Quarterly Report #1, 2019-3
RCLQRT-19V520-3018.PDF 211.129KB
Latest Recalls Documents
- VIABRICO Wire : 14 gauge Copper Clad Aluminium wire, 100ft/30.5m each spool. 6 different colors (red, black, white, blue, green, yellow) totaling 600 feet. high mechanical strengthfeatures, flame retardant, anti-aging, acid and alkali resistance and dampproof.
- Convenient to Use: This low voltage wire is easy to strip and cut into any length based on needs. Wire comes wrapped around a hard plastic spool that makes dispensing convenient. 6 jacket colors make for quick and easy to distinguish the polarity and numbered markings for accuracy.
- Perfect Performance: Wire operating temperature rating of -20℃ of 70℃ respectively. The hook-up wires are designed to operate under stringent conditions. The jacket material is flexible and environmental friendly PVC, which can be twisted and extended it freely as you like.
- Advantage of Copper clad aluminum: CCA wire offers the same signal frequency and reliability in terms of corrosion resistance to copper wire. The advantage of the CCA wire is lighter and more flexible than copper wire. The cost of CCA vs Oxygen free copper is much lower and you can enjoy the same functions and reliability as copper wire without paying the extra cost for the installation.
- Wide Range of Applications : VIABRICO 14 awg wire is widely used in automotive, remote control models, batteries, lamps, electrical appliances, motor cables, digital 3D printers, remote control applications, power tools, electric toys, robots and other electrical appliances and electric DIY.
- [Copper Clad Aluminum (CCA)] CCA wire offers the same signal frequency and reliability in terms of corrosion resistance to copper wire. The advantage of the CCA wire is lighter and more flexible than copper wire. The cost of CCA vs Oxygen free copper is much lower and you can enjoy the same functions and reliability as copper wire without paying the extra cost for the installation.
- [Wide Compatibility] Electrical wire widely used in monochromatic LED strips, model cars, marine, low voltage wires, light bulbs, power/ground for indoor lighting, low loss home appliances or car audio installations, etc.
- [Low Voltage Wire] electrical wire is made of 16 AWG 100FT with red and black 2 conductors and high quality PVC jacket, good conductivity, high mechanical strengthfeatures, flame retardant, anti-aging, acid and alkali resistance and dampproof.
- [Perfect Performance] Wire operating temperature rating of -20℃ of 70℃ respectively. 2 conductor wire is flexible, durable and easy to bend, so that you can better separate the two wires in use without exposing the wires inside.
- [Best Service] Please feel free to contact us if you have any problems with our automotive wire, we will make every effort to help you.
- 16 Gauge Auto Electrical Wire : Come in 2 colors (Black/Red) rolls of 25ft 16 gauge auto wire. 12V/24V DC Cable.
- Copper Clad Aluminum Wire : The CCA Cable can provide the same signal frequency and reliability as pure copper wire, and is lighter and more flexible than copper wire.
- Ultra Flexible PVC Jacket : Adopting high-quality flexible PVC jacket, it is resistant to high temperature and drought, and is also very easy to install.
- Wide Application : 16awg stranded hookup wires are widely used for Car Audio, electrical equipment, model cars/ ships, lamps household applications, speaker audio, meters instruments, security alarm control, electric toys and more.
- Worry Free Service : If you have any questions about our products, please feel free to contact our reliable customer service and we will reply to you within 24 hours.
- VIABRICO Wire : 12 gauge Copper Clad Aluminium wire, 100ft/30.5m each spool. 6 different colors (red, black, white, blue, green, yellow) totaling 600 feet. high mechanical strengthfeatures, flame retardant, anti-aging, acid and alkali resistance and dampproof.
- Convenient to Use: This low voltage wire is easy to strip and cut into any length based on needs. Wire comes wrapped around a hard plastic spool that makes dispensing convenient. 6 jacket colors make for quick and easy to distinguish the polarity and numbered markings for accuracy.
- Perfect Performance: Wire operating temperature rating of -20℃ of 70℃ respectively. The hook-up wires are designed to operate under stringent conditions. The jacket material is flexible and environmental friendly PVC, which can be twisted and extended it freely as you like.
- Advantage of Copper clad aluminum: CCA wire offers the same signal frequency and reliability in terms of corrosion resistance to copper wire. The advantage of the CCA wire is lighter and more flexible than copper wire. The cost of CCA vs Oxygen free copper is much lower and you can enjoy the same functions and reliability as copper wire without paying the extra cost for the installation.
- Wide Range of Applications : VIABRICO 12 awg wire is widely used in automotive, remote control models, batteries, lamps, electrical appliances, motor cables, digital 3D printers, remote control applications, power tools, electric toys, robots and other electrical appliances and electric DIY.
- 18 Gauge silicone wire - super flexible 150 strands of 0.08 mm Tinned copper wire - protecting them from corrosion and making it easier to solder.Highly efficient - Super low impedance .
- 18 Gauge Wire Due to the Silicone insulation and fine stranded core, The wire is very flexible easy to strip and solders . Well suited for applications where the wire will be flexed, like test cables. Could be terminated with pins and heat shrink sleeves for breadboard jumper wires.
- 18 Gauge Silicone Wire High Temperature Resistant.Temp: -60 degree celsius +200 degree celsius ,Low temperature resistance,in extreme cold -60 degree celsius
- Conductor: High-purity oxygen-free Tinned Copper,Nominal Voltage 600V；Bear Current 7.5A
- 18 Awg Stranded Wire :(6 different colored 4 Meters /13.2 Feet spools) colors:red,yellow,white,green,blue,black
Last update on 2026-05-23 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.