June 24, 2020 NHTSA CAMPAIGN NUMBER: 20V370000
Loose Wiring Connector May Short and Cause Fire
If the CCP1 electrical connection short circuits, there would be an increased risk of a fire.
NHTSA Campaign Number: 20V370
Manufacturer Triple E Recreational Vehicles
Components ELECTRICAL SYSTEM
Potential Number of Units Affected 10
Summary
Triple E Recreational Vehicles (Triple E) is recalling certain 2020 Wonder W24RTB, W24MB, and W24FTB motorhomes built on a Ford
transit chassis. The CCP1 electrical connection located on the driver’s seat base was not tightened to the correct specification and may short circuit.
Remedy
Triple E has notified owners, and dealers will tighten the electrical connection to specification, free of charge. This recall began June 26, 2020. Owners may contact Triple E customer service at 1-877-992-9906. Triple E’s number for this recall is CA#9711-1.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SOP02673
RECREATIONAL VEHICLES
QAAR 9711 Ensure Correct Torque Applied to CCPl Electrical Connection
Department: 32
People Required: 1
Time to Complete: 2 min
Date Created: June 24, 220
Date Revised: Rev#:
Created by Initial: GK Verified: DP
1
Make sure all power is off in the coach:
1. Shore Power Unplugged
2. Battery Disconnect OFF
3. Keys not in ignition
2
Open the driver’s door and look at the base of the chair pedestal behind the rear of the cab door pillar for the CCP1 connection point.
3
Remove the cover by gently pulling on the top tab away from the seat.
4
Using a 10mm (13/32″) socket, back off the M5 nut until it spins freely.
5
Use a torque wrench to apply 35in/lbs to the nut.
6
Snap cover back over connection point, make sure it clicks
IMPORTANT SAFETY RECALL
June 25, 2020
«Owner Name»
«Address 1 »
«Address2»
«Address3 », «Prov» «Postal Code»
“This notice applies to your vehicle,
«Unit»
VIN #«VIN»
Coach Serial #«Serial»
Triple E Recreational Vehicles Recall CA#9711-1
20V370
This notice is sent to you in accordance with the requirements of the National Traffic & Motor Vehicle Safety Act. Triple E Recreational Vehicles has decided that certain 2020 Wonder motorhomes manufactured between May 4, 2020 & May 28, 2020 fail to conform to Federal Motor Vehicle Safety Standard
Description of Safety Defect:
The CCP I connection, located on the driver seat base, has not been torqued to the specified torque requirement. There is a possibility that the nut on this connection may come loose causing a short in the electrical, which could cause a fire and bodily injury.
To Have This Modification Performed:
We request your assistance to have this Safety issue corrected. Please follow the enclosed SOP02673 (Standard Operating Procedures) to perfmm the Recall. If you choose to have your selling dealer or a RV service center perform the recall it will be performed at no charge to you. The time needed to perform the recall is approximately 6 minutes. If you choose to have this Recall performed by a service center other than your dealer, prior authorization is required.
If you had this repair performed before you received this letter, you may be eligible to receive reimbursement for the cost of obtaining a prenotification remedy of the problem associated with this recall.
For more information contact Triple ERV/Leisure Travel Vans at 1-877-992-9906 Customer Service/ Warranty department or by e-mail [email protected] in the subject line “Recall CA#9711-1”.
For U.S. Residents
If Triple E Recreational Vehicles fails or is unable to remedy this potential defect without charge, you may submit a written complaint to the Administrator, National Highway Traffic Safety Administration, 1200 New
Jersey Ave. SE, Washington, DC 20590 or call the toll free Vehicle Safety Hotline at 1-888-327-4236; (TTY: 1-800-424-9153) or go to https://www.safercar.gov
We regret the inconvenience this Recall may cause you but want you to have complete satisfaction with your Leisure Travel Vans product. Thank you for your anticipated assistance and please do not hesitate to contact us should you require additional information.
Sincerely,
Brad Wall
Customer Service/ Warranty Manager
BW/wcw
Enclosure
1 SOP02673 (Standard Operating Procedures)
IMPORTANT SAFETY RECALL
June 25, 2020
«First Name»
«Address Line 1 »
«City», «State» «ZIP Code»
“This notice applies to this vehicle,
«ProductLine»
VIN #«Vin»
Coach #«UNIT CoachID»
Triple E Recreational Vehicles Recall CA#9711-1
20V370
This notice is sent to you in accordance with the requirements of the National Traffic & Motor Vehicle Safety Act. Triple E Recreational Vehicles has decided that certain 2020 Wonder motorhomes manufactured between May 4, 2020 & May 28, 2020 fail to conform to Federal Motor Vehicle Safety Standard
Description of Safety Defect:
The CCP 1 connection, located on the driver seat base, has not been torqued to the specified torque requirement. There is a possibility that the nut on this connection may come loose causing a short in the electrical, which could cause a fire and bodily injury.
To Have This Modification Performed:
We request your assistance to have this Safety issue corrected. Please follow the included SOP02673 (Standard Operating Procedure) to perform the recall. For reimbursement submit a warranty application form.
Labour to perform this Recall: 0.1 hrs/ unit
For more information contact Triple ERV/Leisure Travel Vans at 1-877-992-9906 Customer Service/ Warranty department or by e-mail [email protected] in the subject line “Recall CA#9711-1”.
Thank you for your anticipated assistance and please do not hesitate to contact us should you require additional information.
Sincerely,
Brad Wall
Customer Service/ Wananty Manager
BW/wcw
Enclosure
1 SOP02673 (Standard Operating Procedure)
3 Affected Products
Vehicles
| MAKE | MODEL | YEAR |
| WONDER | W24FTB | 2020 |
| WONDER | W24MB | 2020 |
| WONDER | W24RTB | 2020 |
10 Associated Documents
Recall Quarterly Report #1, 2020-2
RCLQRT-20V370-2534.PDF 211.147KB
Miscellaneous Document- Return Form
RMISC-20V370-4919.pdf 31.664KB
Miscellaneous Document
RMISC-20V370-3933.pdf 1042.218KB
Manufacturer Notices(to Dealers,etc)
RCMN-20V370-1456.pdf 245.671KB
ISSUED Owner Notification Letter(Part 577)
RCONL-20V370-3489.pdf 401.656KB
Recall Acknowledgement
RCAK-20V370-3990.pdf 244.683KB
Defect Notice 573 Report
RCLRPT-20V370-6907.PDF 213.961KB
Recall Quarterly Report #3, 2020-4
RCLQRT-20V370-6155.PDF 211.33KB
Recall Quarterly Report #4, 2021-1
RCLQRT-20V370-8287.PDF 211.435KB
Recall Quarterly Report #2, 2020-3
RCLQRT-20V370-4330.PDF 211.238KB
Latest Recalls Documents
- 【Powerful Battery Starter】The OXILAM car jump starter delivers a powerful peak current of 6000A, capable of quickly reviving a dead car battery in just seconds—even in extreme temperatures. A single full charge provides up to 60 jumpstarts. 2024 upgraded jumper cables can safely start all gas engines and 12L diesel engines, including 12v vehicles, motorcycles, pickups, RVs, tractors, trucks, vans, ATVs, snowmobiles, yachts, and many more. Say goodbye to being stranded due to a dead battery
- 【Multiple Security Protections】The OXILAM car battery jump starter features an integrated battery and intelligent clamps design, equipped with 10 intelligent safety protections to guard against short circuits, reverse polarity, sparks, and so forth. With enhanced thermal efficiency and power management, it ensures better performance and extends battery life, safeguarding the car battery starter from potential damage due to overheating, loose connections, battery bulging, and expansion
- 【Multifunctional Car Emergency Kit】This is an all-in-one car emergency kit that serves as a car jump starter, portable power bank and LED flashlight. It features 2 USB output ports (5V/3A, 9V/2A, 12V/1.5A), allowing for a 75% time saving when charging your mobile phone, tablet, Kindle, or digital camera. The device also boasts an upgraded Type-C input port(5V/3A, 9V/2A, 12V/1.5A)for faster charging. Additionally, it offers three 800-lumen LED light modes: flashlight, strobe, and SOS
- 【Sturdy and Considerate Design】This car jumper starter portable features a sturdy, waterproof shell and includes a protective cover to guard against wear and tear. The non-slip side design ensures a secure grip. Its ultra-compact and lightweight design allows for easy placement in your bag or car without taking up space. The battery jumper box is equipped with an LED screen that displays the battery status, providing an intuitive view of the battery's condition and remaining power
- 【Reliable Product Coverage】OXILAM battery jumper starter portable supply provides manufacturer protection and lifetime reliable Technical Support. Our 24-hour online after-sales team is ready to address any issues you may have. If you have any questions about the jump start battery pack get in touch with us for a satisfactory solution
- POWERFUL CAR BATTERY JUMP STARTER: The ET03 car battery jump starter can easily jump-start all 12V common vehicles with up to 8.0L gas and 7.0L diesel engines in seconds with its peak current reaching 4000 amps. Supports 50 jump starts at most on a single charge and suitable for lawnmowers, motorcycles, passenger cars, trucks, and even boats, etc.
- STARTS 0V DEAD BATTERIES EASILY: This car battery jump starter has integrated the force start function in the jumper clamps, which delivers powerful performance to bring your vehicle back to life even if the vehicle has a completely dead battery at 0V. Please make sure this battery jump starter is fully recharged or above 14V if you want to use this jump starter on a car with a dead battery.
- BACKUP PORTABLE POWER BANK: This jump starter battery pack can also work as a 74Wh large battery capacity portable power bank to charge your smartphones, tablets, or other USB electric devices. Two 5V/2A USB output ports are packed on this jump starter that can be applied at the same time for charging, 50% faster than a standard charger.
- PACKED WITH LED EMERGENCY LIGHT AND BONUS FEATURES : the ET03 car jump starter is packed with a 500-lumens LED flashlight to provide help in darkness or for emergency situations that support three variable light modes (stable, strobe, and SOS). There are more features included such as an LCD screen to check the battery status, a wide working temperature from 14℉ to 140℉, and 24 months long standby time.
- 10 INTELLIGENT SAFETY PROTECTIONS: This jump starter battery pack is super safe to use with 10 intelligent safety protections against overcharge, short circuits, reverse polarity, power surging and sparking, and so forth. You can detect the errors by simply checking the lights and the beep sound from the smart jumper clamps.
- 7000A Peak Current & Broad Compatibility – Equipped with a high-rate lithium battery, this portable jump starter delivers 7000A peak current to instantly revive dead batteries. It safely jump-starts All gas and 12.0L diesel engines, including cars, motorcycles, SUVs, pickups, boats, and lawnmowers. A must-have emergency roadside assistant for your garage.
- "Forced Start Button" FOR FULLY DRAINED BATTERIES – Our smart cable features an override "Forced Start Button" . If your battery is completely dead, pressing the forced start button can quickly start the car. and get back on the road.
- 14-WAY SAFETY WITH METAL CLAMPS – No more flimsy plastic clips. Sharmeal features heavy-duty metal clamps and 14 smart protections. From reverse polarity, over current, and short circuit to low temperature protection, spark resistance, and impedance matching—this jump starter guards against it all. Safe for beginners, reliable for pros. Your ultimate 12V portable jump box.
- PORTABLE EMERGENCY TOOL – Measuring just 7.8*3.4*1.5" and weighing only 0.99 lbs. this compact jump starter is 80% smaller than traditional lead-acid boosters. It combines a portable power bank for your iPhone (USB port) and a 3-mode LED flashlight (Strobe/SOS). Perfect for men and dad, or keeping in your glove box for peace of mind.
- What You Get–Our Brand is specialized in vehicle emergency starter with 24 months warranty. Sharmeal jump pack (1* jump starter, 1* smart jumper cables, 1* type-C charging cable, 1* user manual, 1* portable carrying case).Please note that the charger and charging cable are placed in carrying case.
- [Emergency Save Dead Batteries] - Safely, stable and powerful, you can start a dead car battery in seconds, Gehopow jump starter with 6000A peak current for up to 10.0L gasoline or 8.0L diesel, suitable for 12v vehicles like car, suv, truck, van, motorcycle.
- [Waterproof Protection] - We hope users feel 100% safe when using our car battery jump starter. So we design the car jump starter with IP66 waterproof and dustproof, you can use it even in the rainy day.
- [Not Just a Car Tool] - This jump box is equipped with USB output port, can charge for phones, tablets, and other USB devices. Press 3 seconds can start the LED flashlight, with 3 light modes, including lighting, flash and SOS. The red sos light can be used as a emergency light.
- [Humanized and Advanced] - powerful and compact, the size of car jumper starter portable is 7.0*3.5*1.6 inches. Almost the size of a phone and with 1.7pound of weight is easy to carry. Featuring high-discharge lithium technology for safe, stable and efficient operation in any climate.
- [Package include] - A9 car jump starter*1, jumper cables*1, USB Type-C charging Cable*1, user maunel*1, storage case*1. Our after-sales customer service is available at any time. Please contact us for help.
This product presentation was made with AAWP plugin.