U-Bolts Securing Front Axle May Fail – 2019-2022 Oshkosh S-Series

January 11, 2022 NHTSA CAMPAIGN NUMBER: 22V009000

U-Bolts Securing Front Axle May Fail

Bolt failure may allow the front axle to shift or detach, increasing the risk of a crash.

 

NHTSA Campaign Number: 22V009

Manufacturer Oshkosh Corporation

Components SUSPENSION

Potential Number of Units Affected 1,268

 

Summary

Oshkosh Corporation (Oshkosh) is recalling certain 2019-2022 S-Series vehicles. The u-bolts securing the front axle may fail.

 

Remedy

Oshkosh will provide new u-bolts, free of charge. Owner notification letters were mailed February 24, 2022. Owners may contact Oshkosh customer service at 1-888-686-7278.

 

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

 


Purpose:

A concern affecting safety exists in some Oshkosh S-Series Front Discharge Mixers. Vehicles have been identified that are equipped with front axle U-bolts that were manufactured incorrectly and do not meet the required material specifications. The defect may cause the front axle U-bolts to loosen or fall off, resulting in the front axle shifting or the axle becoming dislocated from the vehicle. This bulletin provides instruction on replacing the front axle U-bolts.

 


Oshkosh Corporation Classification – Restricted

Chronology:

In late July 2021, Oshkosh was made aware of a customer report of noise coming from the front end of a model year2020 vehicle.  The vehicle was relatively new and had been in service for only approximately one year.  The report only included a general observation that the driver had noted a popping noise during turning maneuvers but could not locate the source of the noise.

The customer was advised to have the vehicle inspected and in July 2021, Oshkosh technicians inspected the vehicle and found visible deformation to the U-bolts in the front axle.  The U-bolts were replaced, but thereafter the customer again reported noises from the vehicle in the area of the front axle.

Following the customer’s second report, Oshkosh’s investigation began to focus on the properties of the U-bolts to understand whether they may have some influence on the noise being reported by the customer.  In August 2021, Oshkosh’s certified materials laboratory began an analysis of these Ubolts.  Oshkosh also collected samples of U-bolts from other production lots.  Testing was conducted through early Fall 2021 to evaluate the material properties of the U-bolts.

After testing multiple samples of U-bolts, and throughout various part lots, it was determined that certain sets of the bolts did not meet the engineering specifications for material hardness.  Thereafter, Oshkosh contacted the manufacturer of the subject U-bolts to understand what may have led certain sample parts to not meet the material specifications.  The supplier’s investigation confirmed that these samples did not meet the specifications for the U-bolts.

In the Fall, 2021, Oshkosh began to evaluate the potential impact of a U-bolt that did not meet the engineering specifications for hardness when installed at the front axle.  This analysis consisted of engineering simulations and in-vehicle testing as well as an evaluation of whether the U-bolts that did not meet material hardness meet specification for clamping load.   Oshkosh also worked with the supplier to identify the affected production lots and to correlate those with vehicle production.  This evaluation and analysis lasted through the end of 2021.

January 5, 2022- Oshkosh determined that this issue was a safety issue and would go to the field with a Safety Recall to fix the affected population of vehicles.

To date, Oshkosh has only received the single customer report.  Oshkosh has not received reports of any incidents involving the front axle becoming loose, shifting out of place or detaching from the vehicle in the field, but out of abundance of caution is going to the field to correct this issue.

 


4 Affected Products

Vehicle

MAKEMODELYEAR
OSHKOSHS-SERIES2019-2022

 


12 Associated Documents

Recall Acknowledgement

RCAK-22V009-6757.pdf 645.588KB

 


Chronology

RMISC-22V009-9637.pdf 60.958KB

 


Defect Notice 573 Report

RCLRPT-22V009-8324.PDF 212.967KB

 


Remedy Instructions and TSB

RCRIT-22V009-0498.pdf 994.912KB

 


Recall 573 Report- AMENDMENT 1 (02/24/2022)

RCLRPT-22V009-8743.PDF 212.965KB

 


Recall 573 Report- AMENDMENT 2 (02/24/2022)

RCLRPT-22V009-2785.PDF 212.96KB

 


Recall 573 Report- (03/02/2022)

RCLRPT-22V009-9544.PDF 213.017KB

 


Recall Quarterly Report #1, 2022-1

RCLQRT-22V009-4610.PDF 211.119KB

 


Recall Quarterly Report #2, 2022-2

RCLQRT-22V009-5000.PDF 211.225KB

 


Recall Quarterly Report #3, 2022-3

RCLQRT-22V009-4358.PDF 211.308KB

 


Recall Quarterly Report #4, 2022-4

RCLQRT-22V009-5426.PDF 211.415KB

 


Owner Notification Letter(Part 577)

RCONL-22V009-4376.pdf 186.438KB

 


Latest Recalls Documents

 


 

Bestseller No. 1
SPARKWHIZ Trailer U Bolt Kit 7" for 5,200-7,000 lb Trailer, 2 Pack
  • For 5,200 - 7,000lbs round axle which axle beam dia 3"
  • 8 x 7" long U bolts, U bolts dia. 1/2", 16 x 1/2"-20 hex nuts, 4 x tie plates for 1-3/4" leaf springs
  • Durable steel construction. Resistant to rust and corrosion
  • Enhances performance of your braking system
  • Facilitates easy installation
Bestseller No. 2
Dorman 929-724 Rear Leaf Spring Axle U-Bolt Kit
  • Reliable hardware - the components in this leaf spring axle U-bolt kit are designed to securely hold the leaf spring or leaf spring bundle to the underside of a vehicle or trailer axle
  • Check fit - carefully review the dimensions of the leaf springs that will be used and other relevant application details to select the right type and size U-bolt kit for your needs
  • Durable construction - the components in this kit are engineered from quality materials for reliable performance and long service life
  • Trustworthy quality - backed by a team of product experts in the United States and more than a century of automotive experience
  • Ensure fit - to make sure this part fits your exact vehicle, input your make, model and trim level into the garage tool
Bestseller No. 3
SPARKWHIZ Trailer U Bolts for 3,500 lb Trailer, 5-1/2" Long
  • For 3,500lbs round axle which axle beam dia 2-3/8"
  • 4 x 5-1/2" long U bolts, U bolts dia. 1/2", 8 x 1/2"-20 hex nuts, 2 x tie plates for 1-3/4" leaf springs
  • Durable steel construction. Resistant to rust and corrosion
  • Enhances performance of your braking system
  • Facilitates easy installation
Bestseller No. 4
Dorman 929-723 Rear Leaf Spring Axle U-Bolt Kit
  • Reliable hardware - the components in this leaf spring axle U-bolt kit are designed to securely hold the leaf spring or leaf spring bundle to the underside of a vehicle or trailer axle
  • Check fit - carefully review the dimensions of the leaf springs that will be used and other relevant application details to select the right type and size U-bolt kit for your needs
  • Durable construction - the components in this kit are engineered from quality materials for reliable performance and long service life
  • Trustworthy quality - backed by a team of product experts in the United States and more than a century of automotive experience
  • Ensure fit - to make sure this part fits your exact vehicle, input your make, model and trim level into the garage tool
Bestseller No. 5
Rough Country 1/2" Round Suspension U-Bolts | 1/2 x 3 x 8-7639 Black
  • Heavy-Duty: Replace worn suspension U-bolts with durable, steel construction designed for strength and reliability.
  • Corrosion Resistant: E-coated black finish protects against rust and the elements for long-lasting performance.
  • Perfect Fit: Available in the ideal size for suspension, custom fittings or replacements. Specifications: Round style, thread size 1/2", 3" width x 8" length.
  • Easy Installation: Sold as a set of 4 U-bolts for quick and easy upgrades. Typical install time is 2-3 hours.
  • Lifetime Protection: Backed by Rough Country's Limited Lifetime Replacement Warranty for trusted quality.

 


This product presentation was made with AAWP plugin.

Leave a Comment

Share to...